The correct operation method of organic fertilizer tipping machine

 At present, the main types of dumpers in China are self-propelled dumpers and trough dumpers. The difference between them is that the self-propelled dumper works by walking with four tires. The trough dumper needs to build a fermentation tank and put the dumper frame on the tank to work.


Before turning over

1. Cannot drive the compost window opener in an area exceeding 5 degrees.

2. Check whether the screw parts of the compost machine are loose. Tighten the loose bolts before starting the organic manure composter.

3. Check that the chain and belt of the compost harvester are loose.

4. Check whether water is added to diesel oil, hydraulic cylinder, diesel water tank and compost water tank.

5. Check whether the battery is powered up. In the process of turning over the pile


In the process of turning over the heap

1. Check whether the materials contain debris such as brick, stone, iron, and glass. Check whether the road surface is smooth, check whether the width of the pile is greater than the width of the running tire. If you exceed the above requirements, please clean up before starting to turn the pile.

2. Flip the compost to the pile. Make sure that the vertical center line of the composter is aligned with the pile and that the horizontal center line of the composter is parallel to the horizontal center line of the pile.

3. Adjust the accelerator to idle state. Lower the roller to its lowest point 3mm above the ground. Switch on the hydraulic clutch, turn the throttle to full, then shift the front gear and start steering with first gear.

4. It is strictly prohibited to stand before and after the compost organizer.

5. Turn off the hydraulic clutch switch at the end of the pile rotation. Raise the roller to the highest point and set the accelerator to run normally.

After turning over

1. Clean the material under the organic manure composter or on the roller.

2. Maintain the compost machine according to the instructions.

3. Turn off the power switch when the compost harvester is not in use.

4. When the machine stops, the motor should not be cut off immediately. Reduce the accelerator to idle and turn off the motor after one minute.

评论

发表评论

此博客中的热门博文

Three forms of granulation for processing fertilizers in compound fertilizer production lines

图片
  In the  drum granulator , steam, ammonia gas or phosphoric acid or nitrogen solution, phosphorus ammonia slurry, and barite slurry are introduced into the drum to complete the granulation process of chemical reaction and heat supply in the cylinder; or the cold granulation process of compound fertilizer with a small amount of water is added. The materials to be granulated are rolled and rotated in the cylinder, and agglomerate into balls under certain humidity and temperature, Complete the ball making process. NPK fertilizer granulator  of compound fertilizer is produced by non drying process at room temperature, with one-time molding and output of 1-4t / h. Complete set of equipment process layout compact, scientific and reasonable, advanced technology. Energy saving and consumption reduction, no three wastes discharge, stable operation, reliable operation and convenient maintenance. It is suitable for granulation of compound fertilizer, medicine, chemical industry, fe...
阅读全文

Process flow of producing NPK fertilizer using drum granulator

图片
  Raw materials for preparing granular potash fertilizer by  drum granulator Powdered potassium chloride (0-0-60) or powdered potassium sulfate (0-0-50); binder, including magnesium chloride, magnesium sulfate, magnesium oxide, bitter earth powder; filler, including clay, bentonite, gypsum, etc. Production process of potassium fertilizer granules by drum granulator 1. Water and magnesium chloride (or magnesium sulfate) are added in the reactor according to the proportion, and the solution is formed by stirring and dissolving. Then, powdered magnesium oxide is added according to a certain proportion, and further stirred evenly to form the required magnesium oxychloride hydrate (or magnesium oxysulfide hydrate). 2. The powdered potassium chloride or potassium sulfate is added into the drum  npk fertilizer granulator , and the granulation additive magnesium oxychloride hydrate (or magnesium oxysulfide hydrate) with the mass fraction of 0.5% - 10.0% on dry basis is sprayed in...
阅读全文

How does an organic fertilizer composter produce organic fertilizer from chicken manure?

图片
  Chicken manure  organic fertilizer manufacturing process , the raw materials used include: dry chicken manure 45-50%, fermentation bacteria, cake fertilizer, mud fertilizer, sterilization and deodorant. Biological fermentation and ordinary fermentation are used to produce chicken manure bio-organic fertilizer. The product obtained by the organic fertilizer manufacturing process is a kind of chicken manure bio-organic fertilizer. After application, it can greatly increase the production of food, economy, vegetables, fruits and other crops, improve the quality of agricultural products, and improve crop properties. Environmentally safe and non-toxic, it is a new type of environmentally friendly fertilizer. The characteristics of chicken manure organic fertilizer are as follows: 1、 Chicken manure contains a lot of organic matter because of its short digestive tract. Chicken manure is used as organic fertilizer, which has good fertilizer utilization rate and high nutritional valu...
阅读全文